VW T4 Forum - VW T5 Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 27 Results
  1. T4 Conversions
    Hey to anyone who reads this! My AC stopped working and had my mechanic source the problem, which turns out to be this pipe (see below). Apparently the pipe is custom/worn badly that they cant find any cereal codes on it to find a replica to replace it, and the previous owner is unsure. If...
  2. Electrical
    The Aircon stopped blowing cold at the end of last summer and I finally got it in for repair at my long-trusted local garage a short while ago thinking a re-gas might be sufficient. After confirming that gas was ok they replaced the compressor and discovered that it was not switching off. We...
  3. General T5 Technical
    Hi I have fitted ac to my 1.9 brr 038906016ah ecu full genuine off another van single fan gassed up with 550g gas as per snap on data. I can command it on using Vcds and works fine fun runs and gets cold. I think the coding should be 010031 but still nothing off the button it all lights up as it...
  4. Stolen Van Watch
    Hi everyone, to change the AC control valve on the AC pump/compressor , the one held in by a CirClip . Do you have to DeGass the system ? Anybody Done without doing that? 1. As one person thought did not have to if it was in closed position and no cold air coming through ? 2. another person...
  5. General Technical
    I am clearing out the back of my T4 Caravelle (1999) and I have come across the rear air conditioning unit behind the trim, on the drivers side right at the back. It is not like similar units I have read about, there is no vent on the window. There are tubes going through the floor and seem to...
  6. General T5 Technical
    Hi all, Just trying to establish if this is normal or not to start with. I've got a '10 plate T5.1 GP I bought last year, with factory fitted AC. Now it's started to get a bit nippy down south I've noticed something funky with my heater. It seems to work fine if the direction is pointed down...
  7. Electrical
    Hi guys, I am having a bit of trouble with my ac (manual, single zone). The AC works (compressor and ventilators are running), the thick ac pipe got really cold today while the other one was somewhat warm. However I got no cold air coming out of the vents in the car. Regardless of whether I...
  8. Engine & Gearbox
    Hi, i'm pulling the engine out on my T4 2.5 tdi in order to change the clutch slave cylinder, and a few other jobs that need doing whilst it's out, but i'm a little unsure about disconnecting the air conditioning. Is there a way to remove it without loosing the refrigerant? maybe some of the...
  9. General Technical
    Hey Planning to head off on Friday so tried gassing up the (manual) A/C in my '96 T4 Panel van. Pressure wasnt that bad, but tried adding R134a up to 40PSI and the compressor still wont engage.... so currently no A/C and +30 degrees forecast.... :bhd. Trouble shooting done so far....: 1...
  10. Electrical
    Been looking at fitting AC in the van as we're heading down to Albania/Greece in the summer and its going to be rooooasting! I figure that we could retrofit, but then we'd only be able to use it when engine is running. Best solution I can find is an under bench unit like the Dometic Freshwell...
  11. Vans For Sale
    Excellent condition, low mileage full VW service history. We bought the van brand new and had it converted to our specification by Complete Camper Conversions with no expense spared. The van has air conditioning, rear parking sensors and a removalable tow bar. We had LED running lights, chrome...
  12. Electrical
    Ok I get it, running AC on 12/24V while parked up is exceptionally difficult if not impossible. But the new unit from Dometic (RTX 2000) looks like it 'could' work. Its designed for a truck but I dont see why it wouldn't work in a van.... anyone seen it done before? When I looked at this...
  13. General Van Chat
    Can anyone help here. Just bought a 2005 Caravelle. Spent the last 5 weeks in hot conditions. Discovered a lot of water under the carpet, having tried to sort out the air bag warning light. Could this be in issue with condensate? I also note that the cables serving the seat, exit through large...
  14. General T5 Technical
    T5 2006 2.5 tdi Gas pressure 35-40 Fans spinning Clutch spinning - I assume the compressor is spinning Switch on A/C, lights up and you can hear the change and gas hiss like noise in the dash. I guess this is expected, it's not leaking as I checked pressure a couple of times after. Done Vagcom...
  15. Vans For Sale
    The advertisement is for a VW T4 2.5 Window Van 2002 right hand drive with air conditioning in India blue £7,250 on an `02` plate. Link to photos below: http://www.vwt4forum.co.uk/album.php?albumid=33321 I have owned this van for over four years and covered about 34,000 miles in it. The cam...
  16. General T5 Technical
    Hi All, We have a weird problem with our air-con and hope that someone might have an idea on how to fix it. The vehicle is a 2008 SWB 2.5 automatic camper van (Autosleeper Trident conversion). The problem: when you switch the air con on, it will run for approx 10-15 minutes before stopping...
  17. Vans For Sale
    Lovely VW Transporter T5.1 SWB with air conditioning, low milage of 54,000k and just been serviced and MOT (MOT'd till 21st July 2016) and VAT already paid. New model with date of Registration 20/10/2010. Private seller, purchased as a base model in Nov 13 and professionally converted. Had...
  18. Engine & Gearbox
    Had my 2.5 T5 in a vw today for a assessment on why the air con wasn't working. Turns out a new compressor is needed, the next question was how much?? £1356 was the answer!!!:eek::* just for a compressor fitted. My question is how easy is it to change and does anyone know where to get one from...
  19. General T5 Technical
    Today I fired up my T5 2005 Trendline 1.9 for the first time in a week. The ASR light was illuminated (as the pic below) on the dash. The ASR isn't on, but a VAGCOM check gave the following error. 16916/P0532/001330 - A/C Refrigerant Pressure Sensor (G65): Short to Ground Indeed, air...
  20. Electrical
    Looking for help in sorting out an AC issue. have an imported 2.5 TDI Multivan/caravel year 2000. The ac unit has started to fail. When I start the van the ac unit flashes for a while, when it stops flashing there is no front fan working the fan in the back of the van is working. I have been...
1-20 of 27 Results
Top