VW T4 Forum - VW T5 Forum banner

cat

  1. Will a diesel pass a emissions test with a dummy cat ?

    General T5 Chat
    Was looking into getting a full exhaust system with dummy cat from pptuning . Was wondering will it pass mot , on inspection or emissions? I have a 2006 pre dpf 2.5 AXD engine , the plate value is 0.8 , if I'm looking at the correct number . When getting stuff like this done do you need to...
  2. Help needed with exhaust part number issue

    General Technical
    T4 2002 ex AA 2.5Tdi 102 I ordered a new cat as the pipe has broken as it joins the cat. The pipe that has arrived is about 70mm too long and the hanger that goes into the rubber bush is not in the same place. I received VK8037T Only had the van since Sept 18 and not had to change any...
  3. 800 Special 1.9TD exhaust dilemma

    Engine & Gearbox
    Evening all, the rear silencer of my 1999 bus finally gave up in the week, had a good run (62k / 20yrs) as it looked to be the original part. I’ve ordered a new Klarius replacement and earlier today removed the remaining piece from the centre pipe (not an original part) and while doing so...
  4. CAT - time for a new S/S exhaust?

    Irish Regional Forums
    Hi Folks, after a bit of faffing I finally got under the van earlier and instantly found the reason for the rasping I`m getting on acceleration @2000rpm or above - a lack of connection from exhaust pipe to what I think is the CAT:* - just to check if this is the CAT and if so...is it more...
  5. exhaust centre pipe for 2.5 petrol L reg.

    Wanted
    I need to change my cat but the centre pipe has been bodged on and will need to be cut off. Anyone got one up for grabs. Can collect or i'll pay for courier. thanks Mel T:
  6. Bag of Spanners - intermittent

    Engine & Gearbox
    I have the dreaded "Bag of Spanners" noise, loud, coming from the middle of the underside. I assume it is the catalytic converter breaking up, except it is intermittent. I first noticed it when my foot was on the brake pedal after stopping, leading me to think it might be the brake servo...
  7. MOT Emissions Failure

    Engine & Gearbox
    Hi Guys, my 95 Petrol 2.5 ACU, has failed the MOT on emissions. It did the same last year which turned out to be a temp sensor in the non-maf. I haven't started to get it looked at yet, any one got any suggestions? It has had a new Cat 2 years ago, could it be a faulty CAT, is it over fuelling?
Top