VW T4 Forum - VW T5 Forum banner

Discussions Showcase Albums Media Media Comments Tags Marketplace

1-20 of 28 Results
  1. Engine & Gearbox
    Anybody used the company 2.0 TDI Diesel - Krosfou UK for purchase of a DPF? The cost is not much less than VW themselves (£1,182), however, only available on backorder. I've had the DPF checked by an independent specialist authorised by DPF Doctor (recommended on here). Requires replacement...
  2. Engine & Gearbox
    Hi all, Long story short, a family member is currently driving my 2011 2 litre T5 on the continent and had a breakdown, loss of power, limp mode etc. A Local garage diagnosed it as a stuck EGR valve (stuck open apparently). Rather than repair it there, they offered to blank it (without a remap)...
  3. Welcome to The VW T4 Forums
    Hi all, the other month I changed the cupeling on My 2007 T5 2.5 auto alternator. So front end off then all back together. I drove off and all seemed fine, little did I know the drivers side intercooler pipe was hissing, I went back one and fitted it back in as the pipe had come out of the...
  4. Engine & Gearbox
    Unfortunately my DPF has had it, took it to the DPF Doctor at Surrey DPF cleaning where he took it off, poked a camera down inside it and found the filter material absolutely shredded. I'm looking for a used or reconditioned DPF for a 2007 T5 2.5ltr BNZ. Does anyone know of any places that sell...
  5. Engine & Gearbox
    I have a problem with exhaust gases leaking from close to the turbo. There is a smell of fumes in the cab and soot can be seen on the bulk head. It's a 2007 2.5 tdi, engine code BPC. I had the turbo overhauled last summer by a local turbo specialist. There were other problems with the van last...
  6. Engine & Gearbox
    Hello, I am replacing a CFCA in a 2015 t5. What is the easiest way? Lower the subframe or remove the front and lift it out? Bought an overhauled long block, so I need to swap all parts over. Any special tools I need for this job? Going to blend the EGR and I guess I need to gut the DPF. Would...
  7. Engine & Gearbox
    Hi all. I got my 2.5TDI a few months back. Some time ago (more than a month already) the engine light went on. I got a code reader and got P0471, which is related to the DPF and the differential pressure sensor. I am reading about DPF regeneration and can´t fully get the picture. It is said...
  8. General T5 Chat
    Looks like the authorities will be getting serious about knocking the insides out of DPF's: http://www.telegraph.co.uk/news/2017/10/29/diesel-drivers-face-costly-repair-bill-thousands-driving-illegal/
  9. Engine & Gearbox
    Can anyone out there help me? My 2010 2.0 TDi T5 went into limp mode shortly after the Engine Management light and the DPF light came on. Having looked through all of the forums and suggestions, I replaced the EGR valve but still the same problem. I have since replaced the Mass Air Flow sensor...
  10. Services, Repairs & Maintenance
    VAGNOSTICS UNIT 4A Roxby Road Ind. Estate Shorpe North Lincolnshire DN15 9SU RH Tuning Agents in Lincolnshire, Norfolk & Suffolk VCDS & Dealer Level Diagnostics Cruise Control Retrofit Multifunction Steering Wheel Retrofit Servicing & Repairs Suspension (Bilstein, GAZ, H&R Etc.) Eberspacher...
  11. Engine & Gearbox
    Hi Guys Had to replace the manifold on my 2007 2.5 TDI BNZ recently. Used a replacement manifold from DarkSide, that went well. Unfortunately .... In reassembly the DPF was apparently hard to refit. My indie mechanic was not able to correctly fit the rear-most of the three sensors on the...
    dpf
  12. Engine & Gearbox
    Pulled into the car park yesterday (2009 Caravelle 2.5 130) to be greeted by billowing smoke and burning smell as i opened the door coming from underneath the centre of the van. I quickly got down to look underneath just as the smoking stopped so i couldn't see the exact point of origin, but it...
  13. Engine & Gearbox
    Hi, As can be common with our vans, I was unfortunate to have a clogged DPF recently. The van ended up in limp mode making my 174bhp T5 feel like a complete dog. After much research (of which this forum played a huge part), I decided to get a DPF delete performed by TH Performance / Pendle. I...
  14. Engine & Gearbox
    ***Exhaust pressure sensor fault fixed*** This may save you £80+ for a new Exhaust pressure sensor should your engine light come on with this fault code. Mine kept coming on and in due course I switched it off via my code reader only to have it come back on a few days later. So, with nothing to...
  15. Engine & Gearbox
    Hi all, I am a newbie to the forum, but a long time commercial dubber. I am on my third transporter, its a 2006 LWB 2.5 tdi auto, with BNZ engine. I've had the van for nearly a year and its been superb, but over the last couple of weeks I have noticed (on three occasions now) a large amount of...
  16. Engine & Gearbox
    Hi, I'm hoping someone in the know can help me out. My van is a 2009 model 2.5tdi BNZ manual with 203k miles on the clock. I only bought the van recently and I've fallen foul of the DPF trap. The van was running poorly and the exhaust was blowing from the manifold and the joint between turbo...
  17. General Technical
    I got a dpf fitted on my t4 to meet the london LEZ law, and when i did the guy said to be careful of people trying to steal it as the metals in it are worth several hundred. After a year of it messing up, i decided to remove it again (waste of money i know), im now trying to scrap it for money...
  18. Engine & Gearbox
    I currently do about 70litres of diesel a week over 400ish miles with about half that around town. It regens about twice a week and annoys the hell outta me. Have been considering a DPF removal but would like to know, realistically, how much better is the MPG after the delete? Mine's the 2.5...
  19. Engine & Gearbox
    Not sure if this has been flagged before, but....: http://www.autoexpress.co.uk/car-news/consumer-news/84818/mot-test-fail-dpf-removal
  20. Engine & Gearbox
    Hello all, Been reading the forum a lot these past few days, its great T:. I have read some good threads relating to the questions I am about to ask, but couldn't find the exact answers. I have a 2003 ACV TDi T4 syncro. It has done 120,000 kms which I believe is about 75,000 miles. I was...
1-20 of 28 Results
Top