VW T4 Forum - VW T5 Forum banner
judder
1-12 of 12 Results
  1. Engine & Gearbox
    Nevermind. Not sure what happenned, because I put the hose all the way into the intercooler and pushed down the clip, but now I see one hose came out, so I guess I screwed up there. Need to shrink my hands so I can get it reattached without taking the bumper off...
  2. Welcome to The VW T4 Forums
    Hi I have just got to the bottom of a fault which was an absolute nightmare to diagnose so thought I’d share this knowledge to hopefully save some others from the same experience. I have a 2.0 bitdi 4motion which developed an engine judder at low revs and especially when cold. Computer...
  3. Engine & Gearbox
    Hi, my 68k 102ps T28 has recently developed vibrations through the Wheel from 30-75 mph, (75mph being my max speed). The vibrations are intermittent and sometimes disappear completely. There's is also a slight judder on pull of in first but only on rare occasions. My thoughts with the judder...
  4. Engine & Gearbox
    Hey Guys. We have an 02 plate 2.5 AJT. We have an Allard EGR delete kit fitted and a PPT stainless exhaust (just to give you a better picture!) For a little while, we have noticed something akin to a judder/shudder from the van - this seems to be restricted to first gear when pulling away and...
  5. Engine & Gearbox
    Flywheel? Eng Mounts? Fuelling?? 2.5TDI 2003 T4 888special On my way to work this morning, setting off in a queue, felt a 'lump' and struggled to find the gear. Set off in third and the clutch seemed to be okay being nursed in.. Drove okay - not especially juddery on the clutch or anything...
  6. Steering & Suspension
    Hi everyone The steering wheel on my T4 2.5tdi LWB has a nasty habit of wobbling/ groaning when doing a sharp turn/ on full lock. I've had a look below and it looks like the steering rack is leaking oil, and the reservoir was quite low. I've topped it up but the noise and wobble is still...
  7. Engine & Gearbox
    I know - its another auto box question. Does anyone know if the Transgo Shift Kits are any good? (see link below) http://www.transgo.com/products.php?prd=SK-VW-O1M&homeinclude=catalog&category_id=152&parent_id=46&product_id=63&countdisplay=1&start=0&addcountview=Yes The VW 01N 01M and 01P all...
  8. Engine & Gearbox
    First post! I've had my caravelle for about 8 months and after about 6 it developed an occasional judder at 1500-1800rpm. Tends to be when theres no real demand on the engine (not accelerating hard or uphill) that lasts a couple of secs. Can stop it by taking my foot off the gas or putting my...
  9. Engine & Gearbox
    I've just (a month ago) had the gearbox removed and noisy bearings replaced In my T5. This has fixed the loud whining noise I was experiencing, however since I've had the van back I'm getting a new problem! The van is now juddering a little when pulling away when the engine is cold. Also, gear...
  10. Engine & Gearbox
    Hi after some help please? A few weeks ago my van (2005 1.9 102ps 137,000m) suddenly went really slow as if there was no boost, had a look and found that a boost pipe had popped off the near side of the intercooler due to the little nipple breaking. I replaced the pipe and although it was...
  11. Engine & Gearbox
    Well i took the plunge and had the autobox rebuilt with an extra cooler fitted, but now i have a very specific issue, the garage is a bit stumped, so i thought i would ask here. When cold the bus behaves fine apart from when it goes into 4th (between 1500-2000 reves and early-mid 40s mph). In...
  12. Engine & Gearbox
    Anybody else had this problem? I have a 2011 T5 LWB 140PS 4Motion Kombi. It has a judder (since new) 1600-2000 rpm most noticable in 4,5 and 6th. Its been in the dealers for three weeks, they have replaced the Haldex and prop-shaft without success. The work shop manager is now saying its a...
1-12 of 12 Results
Top