VW T4 Forum - VW T5 Forum banner

slave

  1. Dmf Clutch and slave cylinder replacement in Christchurch 03 102bhp acv t4 caravelle

    Engine & Gearbox
    Hi all, i have a confirmed leaky slave cylinder, as it's a 2003 t4 102bhp acv engined caravelle it has the slave cylinder in the gearbox so might as well suck up the cost and have the lot done in one go…anyone got a ballpark figure and a recommendation for a local specialist to replace the dmf...
  2. Clutch slave cylinder replacement 03 acv 2.5tdi

    Engine & Gearbox
    Hi all, i have a puddle of fluid on the floor and classic slave cylinder failure symptoms….( the master cylinder was replaced along with pedal box before i bought it and that looks all nicely aligned and is bone dry i have had 3 failures of these on previous t4 so i'm deffo not losing fluid...
  3. Hydraulic leak O2G type gearbox pipework?

    Engine & Gearbox
    I've just reassembled everything after a leaking slave cyclinder / dmf /clutch etc. I've just noticed the clutch pedal poor again :-( Had to topup master cylinder again after the weeks use on / off. Not overly exited about pulling it all out again! Turns out the plastic bit that screws into...
  4. Slave cylinder problem. Easy fix

    Welcome to The VW T4 Forums
    Hey guys, total noob here I know. I am trying to see if there is anything wrong with my slave cylinder. I have removed it today. But my question is. Should the green rubber boot be external or internal inside the cylinder? What is the rubber boots purpose!? It's from a vw t4 1996 (2litre...
  5. Clutch slave cylinder rubber in or out?

    Welcome to The VW T4 Forums
    Hey guys, total noob here I know. I am trying to see if there is anything wrong with my slave cylinder. I have removed it today. But my question is. Should the green rubber be external or internal inside the cylinder? It's from a vw t4 1996 (2litre petrol I think) Looking online there are...
  6. replace master and slave cylinder 97 2.5L T4

    Engine & Gearbox
    Hi all. I have a new ( to me ) 97 2.5L Petrol T4 down here in Australia. I have a gear engagment issues where sometimes the clutch will not engage. Have bleed several times and toped up brake fluid. I have decided to change the Master and Slave cylinder....However i cant seem to find a...
  7. Lost all gears!!! Slave Cylinder???

    Engine & Gearbox
    HI I have a '94 2.4d. Driving along today no problems with gear changes or clutch slipping, until i stopped at a junction and then i was not able to select any gear. I can select all gears with the engine turned off. But when engine is on nothing. Its like i haven't pressed the clutch down...
  8. Clutch slave cylinder failure

    General T4 Chat
    VW Caravelle Transporter I have a small motorhome based on a 1997 VW Transporter (T4 - 102 BHP with Intercooler) now with 26500 genuine miles on the clock. Two years ago, the internal clutch slave cylinder was replaced due to a small hydraulic leak. In August 2008 and 6000 miles later, the...
Top