VW T4 Forum - VW T5 Forum banner

tdi

  1. 2.4 TDI (discussion)

    Engine & Gearbox
    Hello! Here are many people who modded their t4 2.4d with turbochargers and intercoolers. But what about a custom head for direct injection, efectivelly turning it into a 1.9tdi with an extra cylinder. (I know this is a dumb idea, especially since the 2.5 tdi exists, but I thought about it and...
  2. 2.5TDI power steering.

    T4 Articles & Information
    Hi every one, 03 Reg, 2.5l TDI, AJT engine. i'm having an issue and cant figure out the best way to go. Recently on a morning when i fire up the van the power steering is really hard to turn one way, Left turns are no problem at all. turning right i have to use both hands and even then it...
  3. T4 ABL later TDI conversion

    Engine & Gearbox
    Pretty sure this has been done to absolute death but havent seen much recently so thought I'd give it a go. Getting tonnes of black smoke out the back of the ABL so soon enough I recon it will be time to either: recon ABL engine or go down the TDI 1Z, AHU, AFN route. However from what I've...
  4. Vw transporter T5 2.0 tdi 2012 engine misfire judder low rpm

    Welcome to The VW T4 Forums
    Hi I have just got to the bottom of a fault which was an absolute nightmare to diagnose so thought I’d share this knowledge to hopefully save some others from the same experience. I have a 2.0 bitdi 4motion which developed an engine judder at low revs and especially when cold. Computer...
  5. 2.5 TDi T4 Caravelle 2001 What's it worth?

    General T4 Chat
    Hi there, Selling my Caravelle, just wondering what it's worth. Here some spec's: 111 kw 151 BHP 5 seats long chassis GPS, Cruise control, heated frontseats, Airco front and back seats luxury fitting thanks for your help!!!
  6. LT 2.5L TDI Engine (ANJ)

    Wanted
    My engine has died so after a replacement. Does anyone have a 2.5 TDI (ANJ) engine from an LT?
  7. Service/Repair St Albans - turbo/lack of power 2.5 ACV

    Engine & Gearbox
    Hi All Looking for recommendations for a 'specialist' in St Albans area. We have a 1996/97 LHD T4 2.5 Tdi ACV with turbo/power problems. Engine starts and runs ok, but lacks power - struggles uphill, and doesn't feel like the turbo is working. Replaced MAF and 2 pin coolant sensor, checked...
  8. Fuel pump relay j17

    Engine & Gearbox
    T5 2.0L TDI 2010 CAAB engine Does anyone know the position of the tank fuel pump relay J17.
  9. Vw caddy 2001 - tdi - air con - heated seats

    Vans For Sale
    CADDY 2001 1.9 TDI - ALH 90 BHP I bought this caddy from friend of mine who needed bigger van for his window cleaning business. This is the highest spec caddy you will find in the very rare black colour I have tidied it up from time when i have bought it. It had a new slip ring, full...
  10. 2001 caddy tdi - a/c heated seats!!!

    eBay Listings
    FOR SALE CADDY 2001 1.9 TDI - ALH 90 BHP I BOUGHT THIS CADDY FROM FRIEND OF MINE WHO NEEDED BIGGER VAN FOR HIS WINDOW CLEANING BUSINESS. THIS IS THE HIGHEST SPEC CADDY YOU WILL FIND IN THE VERY RARE BLACK COLOUR I HAVE TIDIED IT UP FROM TIME WHEN I HAVE BOUGHT IT. IT HAD A NEW SLIP RING...
  11. Vw t5 2.5 tdi clutch - genuine clutch kit

    Parts For Sale
    Hi, Just doing a clear out in my garage and selling bits that I have bought over time for my T5 which now gone. Its for 2.5 TDI T5 130 bhp. 070141015SX - It cost 267 quid at VAG - I am looking for 150 ono. 7E0698151B - Brake pads set for T5 front - 50 quid posted
  12. Help finding a replacement Accelerator cable for TDi conversion

    Engine & Gearbox
    I had to be recovered earlier today as my accelerator cable snapped on my van that has a 1.9 TDi conversion from an AHU engine, I am pretty sure I need MK3 Golf replacement. Any tips where I can get one tomorrow, I only seem to be able to find stock on eBay. Eurocarparts have none and nor do...
  13. Power steering pumps

    Steering & Suspension
    Hello, Im having trouble trying to source a pas pump for my 1.9 td, and was basically wondering if any other t4's share the same pump? I.e 2.5 petrol ect ect. Any help appretiated, its for my tdi conversion and i preferably would like to get on from the scrappers or second hand, thanks.
  14. power steering pumps

    Welcome to The VW T4 Forums
    Hello, Im having trouble trying to source a pas pump for my 1.9 td, and was basically wondering if any other t4's share the same pump? I.e 2.5 petrol ect ect. Any help appretiated, its for my tdi conversion and i preferably would like to get on from the scrappers or second hand, thanks.
  15. 2000 T4 Transporter ACV 2.5 TDI Not Starting

    Engine & Gearbox
    G'Day Gang, My Transporter has died :* not sure why. When my wife started it there was a bad knock/rattle in the cam belt area. It idled for a short time then stopped. Now it will not fire at all but turns over freely. The cam belt has been changed 15k km ago and with the engine being cranked...
  16. TDI conversion - PAS pump belt too long?

    Engine & Gearbox
    I've been living with my conversion for a couple of years now and it's come the time to change the PAS belt. Unfortunately, the replacement belt seems to be too long and even at the max I can tighten it, it still has too much play. The VW belt was 10x648 and the replacement part (non VW) is...
  17. TDI conversion Manchester

    Engine & Gearbox
    Hi, as spring is around the corner and camping trips are in the planning i'm looking for an experienced mechanic to bring my van back to life!!! To convert my current dead abl into a tdi, I already have a tdi engine and wiring loom, ideally a mobile mechanic as the crankshaft has gone on the abl...
  18. Crankshaft dampner pulley

    Engine & Gearbox
    I thought I would give my T4 a once over before I start using it, so I dropped the belly pan to check for leaks etc and it is looking ok, however I noticed that there are cracks all the way around the main bolt on the crankshaft dampner pulley. I take it this means that it is not far from...
  19. T4 SWB 2.5TDI Camper

    Vans For Sale
    Mileage is currently 139529. 02 plate. 2.5tdi. Just serviced September 2015 and MOT September 2016. Fully insulated and carpeted. Cupboards, 3/4 rock and roll, passenger seat swivel with safe, Smev 2burner with sink, 240 hook up, collapsible table, leisure battery with split charge. Tailgate...
  20. lovely t4 2.5 tdi day van

    Vans For Sale
    Hi there and thanks for looking. up for sale is my 1999 vw t4 2.5 tdi the van is currently on 130000 miles and has a full service history till 1250000 i also have loads of receipts and all the origenal vw pack and spare key. the van is mechanical in a lovely condition benefiting from yet...
Top